Procom PCSD25T Installationshandbuch

VENT-FREE GAS STOVEOWNER’S OPERATION AND INSTALLATION MANUALMODELSPCSD25TPCSD25RTQuestions, problems, missing parts? Before returning to your retailer

www.usaprocom.com200047-01A10INSTALLATIONNOTICE: This heater is intended for use as supplemental heat. Use this heater along with your primary heating

www.usaprocom.com11200047-01AThis appliance is factory preset for propane/LP gas. No changes are required for connecting to propane/LP. Only a quali

www.usaprocom.com200047-01A12INSTALLATIONCONNECTING TO GAS SUPPLY CAUTION: For natural gas, check your gas line pressure before connecting heater

www.usaprocom.com13200047-01AINSTALLATIONFigure 8 - Gas ConnectionFigure 7 - Gas Regulator Location and Gas Line Access Into Stove Cabinet* Purchase t

www.usaprocom.com200047-01A14INSTALLATIONFigure 10 - Equipment Shutoff ValveCHECKING GAS CONNECTIONSOpenClosedEquipment Shutoff Valve WARNING: Never u

www.usaprocom.com15200047-01AINSTALLATIONPRESSURE TESTING HEATER GAS CONNECTIONS1. Open equipment shutoff valve (see Figure 10, page 14).2. Open mai

www.usaprocom.com200047-01A16INSTALLATION6. Place pin on log #5 into hole in the left side of log #1 as shown in Figures 16 and 17, page 17.7. Place

www.usaprocom.com17200047-01AINSTALLATIONLog #4Hole for Log #5Log #5Log #7Log #6Hole for Log #7Log #8Figure 16 - Logs #4 and #8Figure 17 - Logs #5, #6

www.usaprocom.com200047-01A18 WARNING: You must operate this heater with the door closed and in the locked position. Make sure screen is installed be

www.usaprocom.com19200047-01A WARNING: You must oper-ate this heater with the screen in place. Make sure screen is installed before running heate

www.usaprocom.com200047-01A2TABLE OF CONTENTSSafety ... 3Qualied Installing Agency ...

www.usaprocom.com200047-01A2011. Turn control knob counterclockwise to the ON position. The main burner should light. Note: Please wait one m

www.usaprocom.com21200047-01AAAAAAAAAAAAAAAREMOTEOFFONLEARNLEARNREMOTE OFFONFigure 20 - Installing Batteries in Remote Control and ReceiverFigure 21 -

www.usaprocom.com200047-01A22OPERATIONFigure 24 - Manual Mode in ON OperationFigure 25 - Manual Mode in OFF OperationSetting°F/°C ScaleThe factory set

www.usaprocom.com23200047-01AOPERATIONREMOTE CONTROL OPERATION NOTESThe Thermo Feature on the transmitter op-erates the appliance whenever the

www.usaprocom.com200047-01A24Approx. 3"-6" Above Top of LogsMore Than 8" Above Top of LogsApprox. 3"-6" Above Top of LogsMore

www.usaprocom.com25200047-01AFigure 30 - Burner and Injector HolderInjectorBurner TubePrimary Air Inlet HolesBURNER INJECTOR HOLDER AND PILOT AIR INLE

www.usaprocom.com200047-01A26TROUBLESHOOTING WARNING: If you smell gas:• Shut off gas supply.• Do not try to light any appliance.• Do not touch any

www.usaprocom.com27200047-01ATROUBLESHOOTINGProblem Possible Cause Corrective ActionODS/pilot lights but ame goes out when control knob is release

www.usaprocom.com200047-01A28TROUBLESHOOTINGProblem Possible Cause Corrective ActionSlight smoke or odor during initial operation.1. Residues from

www.usaprocom.com29200047-01AREPLACEMENT PARTSNote: Use only original replacement parts. This will protect your warranty coverage for parts replaced u

www.usaprocom.com3200047-01ASAFETYIMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, op-erate, or service thi

www.usaprocom.com200047-01A30PARTSMODELS PCSD25T AND PCSD25RTREMOTEOFFONLEARNTEMPLPPILOTOFFON1110123741418-118-618-218-318-418-718-818-51716PCSD25RT16

www.usaprocom.com31200047-01APARTSMODELS PCSD25T AND PCSD25RTThis list contains replaceable parts for your heater. When ordering replacement parts, fo

200047-01Rev. A05/13REGISTER YOUR PRODUCT AT WWW.USAPROCOM.COMIMPORTANT: We urge you to register your product within 10 days of date of installation,

www.usaprocom.com200047-01A41. Do not place Propane/LP supply tank(s) inside any structure. Propane/LP supply tank(s) must be placed outdoors.2. Thi

www.usaprocom.com5200047-01ASPECIFICATIONSPRODUCT FEATURESSAFETY PILOTThis heater has a pilot with an Oxygen Deple-tion Sensing (ODS) safety shutoff s

www.usaprocom.com200047-01A6WATER VAPOR: A BY-PRODUCT OF UNVENTED ROOM HEATERSWater vapor is a by-product of gas combus-tion. An unvented room heater

www.usaprocom.com7200047-01AAIR FOR COMBUSTION AND VENTILATION WARNING: This heater shall not be installed in a conned space or unusually tight const

www.usaprocom.com200047-01A8DETERMINING FRESH-AIR FLOW FOR HEATER LOCATIONDetermining if You Have a Conned or Unconned Space4. Compare the maximum

www.usaprocom.com9200047-01AVENTILATION AIRVentilation Air From Inside BuildingAIR FOR COMBUSTION AND VENTILATIONFigure 2 - Ventilation Air from Insid