VENT-FREE GASFIREPLACE INSERTOWNER’S OPERATION AND INSTALLATION MANUALMODEL FBD28TQuestions, problems, missing parts? Before returning to your retaile
www.usaprocom.com200014-01A10INSTALLATIONNOTICE: This heater is intended for use as supplemental heat. Use this heater along with your primary heating
www.usaprocom.com11200014-01AINSTALLATIONNGLPINLET GAS PRESSUREMAX 1/2 PSIG (3.5 KPA)NGLPNGLPINLET GAS PRESSUREMAX 1/2 PSIG (3.5 KPA)NGLPFuel Selector
www.usaprocom.com200014-01A12INSTALLATIONBUILT-IN FIREPLACE INSTALLATIONFigure 9 - Rough Opening for Wall InstallationFigure 7 - Clearance to Combusti
www.usaprocom.com13200014-01AINSTALLATIONFigure 11 - Hood InstallationRemove 2 Screws from Top Firebox PanelInsulation BoardReplace 2 ScrewsHoodStep 1
www.usaprocom.com200014-01A14INSTALLATIONCONNECTING TO GAS SUPPLY CAUTION: Avoid damage to regulator. Hold gas regulator with wrench when connecting i
www.usaprocom.com15200014-01AFigure 12 - Gas Connection* Purchase the optional CSA design-certied equipment shutoff valve from your dealer.The instal
www.usaprocom.com200014-01A16Figure 15 - Equipment Shutoff ValveCHECKING GAS CONNECTIONSOpenClosedEquipment Shutoff ValveControl Valve LocationControl
www.usaprocom.com17200014-01ALog #1Log #2Log #3Log #5Burner PortsLog #4PRESSURE TESTING HEATER GAS CONNECTIONSINSTALLING LOGSFigure 18 - Installing Lo
www.usaprocom.com200014-01A18OPERATIONFOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not fol-low these instructions exactly, a re or explos
www.usaprocom.com19200014-01A WARNING: You must oper-ate this heater with the screen in place. Make sure screen is installed before running heate
www.usaprocom.com200014-01A2TABLE OF CONTENTSSafety ... 3Specications ...
www.usaprocom.com200014-01A20INSPECTING BURNERSIMPORTANT: Owner’s should check pilot ame pattern and burner ame pattern often. Incorrect ame patt
www.usaprocom.com21200014-01AApprox. 3"-6" Above Top of LogsMore Than 8" Above Top of LogsApprox. 3"-6" Above Top of LogsMore
www.usaprocom.com200014-01A22Use a vacuum cleaner, pressurized air, or a small, soft bristled brush to clean.A yellow tip on the pilot ame indicates
www.usaprocom.com23200014-01ATROUBLESHOOTING WARNING: If you smell gas:• Shut off gas supply.• Do not try to light any appliance.• Do not touch any
www.usaprocom.com200014-01A24Problem Possible Cause Corrective ActionODS/pilot lights but ame goes out when control knob is released.1. Control k
www.usaprocom.com25200014-01ATROUBLESHOOTINGProblem Possible Cause Corrective ActionSlight smoke or odor dur-ing initial operation1. Residues from man
www.usaprocom.com200014-01A26PARTSMODEL FBD28T2028912287421111819313141516176569752310
www.usaprocom.com27200014-01APARTSMODEL FBD28TThis list contains replaceable parts for your heater. When ordering replacement parts, follow the instru
www.usaprocom.com200014-01A28ACCESSORIESPurchase these heater accessories from your local dealer. If they can not supply these acces-sories, contact P
www.usaprocom.com29200014-01ASERVICE HINTSWhen Gas Pressure Is Too Low• pilot will not stay lit• burners will have delayed ignition• replace will
www.usaprocom.com3200014-01ASAFETYIMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, op-erate, or service thi
www.usaprocom.com200014-01A30NOTES____________________________________________________________________________________________________________________
www.usaprocom.com31200014-01ANOTES____________________________________________________________________________________________________________________
200014-01Rev. A06/13REGISTER YOUR PRODUCT AT WWW.USAPROCOM.COMIMPORTANT: We urge you to register your product within 10 days of date of installation,
www.usaprocom.com200014-01A41. Do not place Propane/LP supply tank(s) inside any structure. Propane/LP supply tank(s) must be placed outdoors.2. Thi
www.usaprocom.com5200014-01AQUALIFIED INSTALLING AGENCYOnly a qualied agency should install and replace gas piping, gas utilization equipment o
www.usaprocom.com200014-01A6PRODUCT IDENTIFICATIONFigure 1 - Vent-Free Fireplace InsertHoodLogsScreenHeater Controls (Behind Panel)WATER VAPOR: A BY-P
www.usaprocom.com7200014-01AAIR FOR COMBUSTION AND VENTILATION WARNING: This heater shall not be installed in a conned space or unusually tight const
www.usaprocom.com200014-01A8DETERMINING FRESH-AIR FLOW FOR HEATER LOCATIONDetermining if You Have a Conned or Unconned Space4. Compare the maximum
www.usaprocom.com9200014-01AVENTILATION AIRVentilation Air From Inside BuildingAIR FOR COMBUSTION AND VENTILATIONOutlet Air Ventilated Attic Outlet A
Kommentare zu diesen Handbüchern